Poulan 186914 Uživatelský manuál

02153OWNER'S MANUALMODEL:PR20PH42STDLAWN TRACTOR Always Wear Eye Protection During Operation WARNING:Read this Owner's Manual and fol l

10AMPS6006002636OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with y

11OPERATIONCAUTION: Always stop tractor com- plete ly, as described above, before leav- ing the operator's position; to empty grass catcher, etc

12OPERATIONLOWPOSITIONTO OPERATE MOWER (See Fig. 9)Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to

13OPERATIONTO START ENGINE (See Fig. 6)When starting the engine for the fi rst time or if the engine has run out of fuel, it will take extra cranking t

14OPERATIONFIG. 1100272 PURGE TRANSMISSIONCAUTION: Never engage or disengage freewheel lever while the engine is run- ning.To ensure proper operation

15BEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil filter)Replace

16MAINTENANCETRACTORAlways observe safety rules when performing any main- te nance.BRAKE OPERATIONIf tractor requires more than six (6) feet stopping

17MAINTENANCECLEAN AIR SCREENAir screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or co

18MAINTENANCEMUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age.SPARK PLU

19SERVICE AND ADJUSTMENTSTRACTORFIG. 1801698RETAINER SPRINGS(BOTH SIDES)RE TAI N ER SPRINGS(BOTH SIDES)ELECTRIC CLUTCHPULLEYFRONT LINKSUS PEN SION ARM

2I. GENERAL OPERATION • Read, understand, and follow all instructions in the manual and on the machine before starting.• Only allow r

2001156SERVICE AND ADJUSTMENTSNOTE: Each full turn of adjustment nut will change mower height about 1/8".• Recheck measurements after adjus

2102537SERVICE AND ADJUSTMENTSTO REPLACE MOTION DRIVE BELT (See Fig. 25)Park the tractor on level surface. En gage parking brake. For as sis tance,

22TO REMOVE WHEEL FOR REPAIRS(See Fig. 26)• Block up axle securely.• Remove axle cover, retaining ring and washers to allow wheel removal (r

23SERVICE AND ADJUSTMENTS02141HOODHEADLIGHTWIRECONNECTORFIG. 29TO REPLACE FUSEReplace with 20 amp automotive-type plug-in fuse. The fuse holder is lo

24STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never

25TROUBLESHOOTING POINTSWill not start 1. Out of fuel.

26TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches

27BATTERYFUSEIGNITIONSWITCHREDREDREDBLACKIGNITIONUNITNON-REMOVABLECONNECTIONSREMOVABLECONNECTIONSBLACKWHITEREDBLACKSTARTERMCLUTCH / BRAKE(PEDAL UP)SOL

282829262442432541272740333050REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33ELECTRICAL22792181D.C. AMPERES451212111082127555

29KEY PART NO. NO. DESCRIPTION1 144927 Battery 2 74760412 Bolt Hex Hd 1/4-20 Unc x 3

3WARNING: In order to prevent ac ci -den tal starting when setting up, trans- port ing, ad just ing or making repairs, al ways dis con nect spark pl

30REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33CHASSIS AND ENCLOSURES642091587430159209132093119157156102614426103331423331

31NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm1 174619 Chassis 2 176554 Drawbar3

32REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33DRIVE29283052323753355536623536223416177772413230525725192426267678757427265

33KEY PARTNO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTIONNOTE: All component dimensions give in

34REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33STEERING ASSEMBLY55434364381040321186874646868729887117439123335346867676713

35KEY PART NO. NO. DESCRIPTIONNOTE: All component dimensions given in U.S. inches.1 inch = 25.4 mm.REPAIR PARTSTRACT

36REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33ENGINE21OPTIONAL EQUIPMENTSpark Arrester291065721326254832313433373339171617

37KEY PART NO. NO. DESCRIPTION1 175437X428 Control Throttle2 171875 Screw Hwhd Hi-Lo #13-

38KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTION1 171684

39103169KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTION1 59192

4PRODUCT SPECIFICATIONSGasoline Capacity 3.5 Gallons and Type: Unleaded RegularOil Type(API-SF-SJ): SAE 30 (above 32°F) SAE 5W-30(below 32

40REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33MOWER LIFT361520161718202015204562316547823242527282930502637414038121131323

41REPAIR PARTSTRACTOR - MODEL NUMBER PR20PH42STD, PRODUCT NO. 954 56 78-33MOWER LIFT1 159461 Wire Asm Inner/Sprg W/plunger2

421514131110981668373031323314614814515018445144545556341464421242526272282923212121181820259194562140143364037401596114911813621139211911711652113421

43KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO. DESCRIPTIONNOTE: All component dim

44SERVICE NOTES

45SERVICE NOTES

46LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an

4715 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

Your POULAN PRO product has been expertly en gi neered and carefully manu fac tured to rigid quality stan dards. As with all mechanical products

5UNASSEMBLED PARTS(1) Large Flat WasherSteering Wheel InsertSteering Wheel(1) Knob(1) Washer 17/32 x 1-3/16 x 12 GaugeSeat(2) Mulch Blades(2) KeysSlo

6Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper o

7ASSEMBLYFIG. 30246602464SEAT PANSHOULDER BOLTADJUSTMENT KNOBFLAT WASHERSEATINSTALL SEAT (See Fig. 3)Adjust seat before tightening adjustment knob.•

8FIG. 5ASSEMBLY02114DEFLECTORSHIELDLATCHHOOKSMULCHER PLATEIMPORTANT: FOR SHIPPING PURPOSES, THE MULCHER PLATE WAS PREATTACHED TO YOUR MOWER. THE MULCH

9These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.OPERATIONDANGER, KEEP HANDS